销售热线:
400-086-0537产品简介/Product introduction
较好催化效果 适合干燥环境下使用
Good catalytic effect is suitable for use in dry environment
霍加拉特催化剂以氧化铜及二氧化锰为主原料,它对干燥环境(常温常压)下的CO具有较好的催化效果。但它的缺点是对 水汽比较敏感,湿度超过45%时,该催化剂很快会中毒失效,因此比较适合在干燥环境下使用。对低浓度CO气体, 该催化剂的效果不及贵金属催化剂显著。
The CO catalyst is mainly composed of copper oxide and manganese dioxide. It has good catalytic effect on dry environment (room temperature and atmospheric pressure). But its disadvantage is that it is sensitive to water vapor. When the humidity is over 45%, the catalyst will quickly become ineffective, so it is more suitable for drying. For low concentration CO gas, the catalyst is less effective than the noble metal catalyst.
以活性炭为载体,浸渍氯化钙、溴化锂等吸湿性物质而成
适用于自救器丶救生舱
Applicable to self rescuer, life capsule
霍加拉特为黑色圆柱状颗粒,是以活性炭为载体,浸渍氯化钙、溴化锂等吸湿性物质而成,适用于需作气体干燥的各种场合。 主要是与卡加拉特干燥剂配套,应用于自救器、救生舱等产品中。
Hogacar is a black cylindrical particle, which is made of active carbon as a carrier, impregnated with calcium chloride, lithium bromide and other hygroscopic substances. It is suitable for various occasions where gas is dry. It is mainly used in conjunction with the kit, and is applied to the products of self rescuers and lifesaving cabin.
以活性炭为载体,浸渍氯化钙、溴化锂等吸湿性物质而成
使用方法/Usage method
湿度控制45%之下 加装干燥剂
在救生舱及避难硐室内,一般很难将湿度控制在45%以下,因此,如果要使用该类型CO催化剂时,要在催化剂药剂的进气端加装干燥剂,带水汽的空气先经过干燥剂,使其中的水汽被吸收滤除,然后让干燥的空气经过CO催化剂层, 使其中的CO气体被催化成CO2。
In the life capsule and the refuge chamber, it is generally difficult to control the humidity below 45%. Therefore, if the type of CO catalyst is used, the desiccant is added to the intake end of the catalyst agent, and the air with water vapor is first passed through the desiccant, and the water vapor is filtered out, then the dry air is passed through the CO catalyst layer. The CO gas in it is catalyzed to CO2.
霍加拉特在实际使用时,不要连续使用CO催化剂,而是将CO浓度降到许可范围后,移走CO料层,防止过多水汽穿过时使催化剂中毒。只有当需要处理CO有害气体时,才将CO催化剂料层放到空气净化机上。
Instead of using the CO catalyst in the actual use, hhogallat removed the CO concentration to the permissions and removed the CO layer to prevent the catalyst from poisoning when excessive water vapor passed through. Only when CO harmful gas is needed, will the CO catalyst material layer be put on the air cleaner.
以活性炭为载体,浸渍氯化钙、溴化锂等吸湿性物质而成
产品参数/Product parameters
视密度:0.65-0.95g/ml | 机械强度:球磨法不小于70% |
粒度: 直径3.5-2.75mm 不大于2% | 直径2.75-1.5mm 不规定 |
直径1.5-1.0mm 不大于12% | 直径1.0mm 以下不大于0.6% |
活性:以相对湿度90%以上的空气,以360ml/min的流量,通过25摄氏度,直径28mm,内装19ml干燥剂的试样管 | |
出气中水气分压为:15min不大于227Pa | 30min不大于333Pa |
60min不大于467Pa |
产品参数/Product parameters
霍加拉特催化剂是一种高度活性的过渡金属氧化催化剂是针对矿用救生舱、避难硐室等煤矿井下紧急避险空间专门研发的一氧化碳常温脱除催化剂。该类型催化剂由过渡金属负载在活性炭加工制成,属于过渡贵金属体系催化剂。
坚持”诚信兴业,合作共赢“的经营理念
诚信经营 源于品质
厂家直销 高品质 优服务
霍加拉特催化剂以氧化铜及二氧化锰为主原料,它对干燥环境(常温常压)下的CO具有较好的催化效果。但它的缺点是对水汽比较敏感,湿度超过45%时,该催化剂很快会中毒失效,因此比较适合在干燥环境下使用。对低浓度CO气体,该催化剂的效果不及贵金属催化剂显著。
霍加拉特催化剂在救生舱及避难硐室内,一般很难将湿度控制在45%以下,因此,如果要使用该类型CO催化剂时,要在催化剂药剂的进气端加装干燥剂,带水汽的空气先经过干燥剂,使其中的水汽被吸收滤除,然后让干燥的空气经过CO催化剂层,使其中的CO气体被催化成CO2。
此外,在实际使用时,不要连续使用CO催化剂,而是将CO浓度降到许可范围后,移走CO料层,防止过多水汽穿过时使催化剂中毒。只有当需要处理CO有害气体时,才将CO催化剂料层放到空气净化机上。
在一个密闭空间内,使用电化学的CO传感器很容易报警,这并不说明密闭体内CO超标,可能是氮氧混合物引起电化学式传感器误报警。比较精确的做法是采用红外CO传感器,此设备得到的CO数据相对准确。